Fault tolerant architecture design of EHA
-
摘要: 一体化电液作动器(EHA, Electrical Hydrostatic Actuator)是功率电传(PBW, Power by Wire)飞控操纵系统的一部分,为了保证整个飞控系统的可靠度,必须采用多余度结构配置.飞控系统分别从可靠度、任务成功率、余度和故障管理水平以及性能、重量等角度提出了EHA的设计指标要求,并按照设计指标要求,对EHA各个组成部分的失效率进行了计算.根据计算结果,针对一种可行的EHA容错结构,分别计算了由于EHA故障导致的任务中断率(PMA, Probability of Mission abort)和失控率(PLOC, Probability of Loss of Control).计算结果表明此种结构形式能够满足飞控系统对作动器可靠度的要求.最后根据选用的可靠度模型,设计出具有容错能力的多余度作动系统,并对此容错结构进行了详细阐述.Abstract: The integrated EHA (electrical hydrostatic actuator) is an important component of the PBW (power by wire) flight control system. Fault tolerant architecture design is necessary to improve the whole reliability of flight control system. Performance parameters were offered by the demand of reliability, mission abort, redundancy, failure management level, performance, weight and size. The failure rate about each EHA-s component was calculated. Based on the calculation result, a feasible fault tolerant architecture of EHA was selected. Then the probability of mission abort and loss of control results from the EHA-s failure were calculated separately. Calculation results show that the fault tolerant architecture can meet the flight control system-s reliability requirement. Detail design about EHA-s architecture was given based on the selected EHA-s reliability model, and this kind of EHA system-s function was described in particular.
-
Key words:
- power by wire /
- electrical hydrostatic actuator /
- redundancy /
- reliability
-
[1] Lyshevski S E. Highperformance directdrive flight actuators:advanced technology demonstration[J].IEEE Conference on Control Applications-Proceedings,1999,2:1229-1234 [2] Corradini M L, Parlangeli G. A fault tolerant control system for the output stabilization of SISO plants with actuator uncertain hysteresis nonlinearities[C]Proceedings of the IEEE Conference on Decision and Control.Piscataway,NJ:IEEE,2003,4:4044-4049 [3] Bolduc L P. X33 redundancy management system[J]. IEEE Aerospace and Electronic Systems Magazine,2001,16(5):23-28 [4] Sadeghi T. Fault tolerant EHA architectures[J]. IEEE Aerospace and Electronic Systems Magazine,1992,7(3):32-42 [5] 李元生. 复合式余度结构的机电作动系统研究[D].北京:北京航空航天大学自动化科学与电气工程学院, 2003 Li Yuansheng. Research on the complex redundancy architecture of EMA[D]. Beijing:School of Automation Science and Electrical Engineering, Beijing University of Aeronautics and Astronautics,2003(in Chinese) [6] 黄洪剑, 林瑞光. 无刷直流电机可靠性及其故障模式分析[J].电机与控制学报,2000,4（4）:198-201 Huang Hongjian, Lin Ruiguang. Analysis of BLDCM reliability and failure model[J]. Electric Machines and Control, 2000,4（4）:198-201(in Chinese) [7] 柳曾兴. 液压系统可靠性分析与计算[J]. 机电设备，1995,5:41-49 Liu Zengxing. Analysis and calculation of hydraulic system[J]. Mechanical and Electrical Equipment,1995,5:41-49(in Chinese) [8] 马纪明,付永领,高波.基于定量反馈理论的EHA控制器设计[J].北京航空航天大学学报,2006,32(5):553-557 Ma Jiming, Fu Yongling, Gao Bo. EHA controller design based quantitative feedback theory[J]. Journal of Beijing University of Aeronautics and Astronautics, 2006,32(5):553-557(in Chinese) [9] 马纪明. 集成电动静液作动器控制系统及余度管理研究[D]. 北京:北京航空航天大学自动化科学与电气工程学院,2006 Ma Jiming. Research on control system and redundancy management of integrated electro hydrostatic actuator[D]. Beijing:School of Automation Science and Electrical Engineering, Beijing University of Aeronautics and Astronautics, 2006(in Chinese) -
点击查看大图
计量
- 文章访问数: 2599
- HTML全文浏览量: 141
- PDF下载量: 1283
- 被引次数: 0
下载:
