-
摘要:
太阳电池阵为航天器提供能源，在型号研制和在轨运营过程中需对其供电能力进行计算，为此提出了一种航天器太阳电池阵供电能力的计算方法。首先，利用太阳电池片的地面测试数据得到标准测试条件（STC）下的电池片伏安模型，并利用电池片在轨等效光强和温度修正电池片伏安模型的光生电流、串联电阻和并联电阻等参数，得到电池片在轨伏安模型，然后，根据基尔霍夫定律推导出电池阵中电池片工作电压、电流以及旁路二极管和隔离二极管的输出情况，从而得到太阳电池阵的伏安模型。仿真结果表明，本文方法可以精确计算航天器在任意光强、温度和遮挡下的太阳电池阵伏安模型，可以精确分析旁路二极管和隔离二极管对太阳电池阵供电能力的影响，较已有方法计算精度提高20%。
Abstract:The solar array supplies power to spacecraft. Thus, it is important to predict power supply capability for spacecraft design and certification of on-orbit flight operation, and a calculation method for power supply capability of spacecraft solar array is proposed. The current versus voltage model of photovoltaic cell under standard test condition (STC) was developed using a group of ground test data, and then the parameters of the model such as photon current, cell series resistance, and cell shunt resistance were adapted to on-orbit irradiation intensity, temperature and shadow. According to Kirchhoff law, the outputs of photovoltaic cell working voltage, current, bypass diodes and block diodes in solar array were obtained, and the model of photovoltaic array was built. Simulation was performed for a typical spacecraft. Results show that this method is applicable to photovoltaic array power capability analysis under arbitrary irradiation intensity, temperature and shadow pattern, the influence of bypass diode and block diode in the solar array is analyzed accurately, and calculation accuracy is improved by 20% compared to traditional method.
-
Key words:
- solar array /
- power supply capability /
- shadow /
- irradiation intensity /
- temperature
-
图 1 太阳电池阵供电能力计算流程
Figure 1. Calculating process of solar array's power supply capability
图 3 标准测试条件下太阳电池片伏安测试数据
Figure 3. I-V test data of solar cell under standard test condition
图 5 不同光强下的太阳电池片I-V曲线
Figure 5. Solar cell I-V curves under different irradiation intensity
图 11 航天器几何模型与太阳电池片电路模型
Figure 11. Spacecraft geometric model and solar cell circuit model
图 14 太阳帆板1电流与太阳入射角余弦关系
Figure 14. Relationship between current of solar array 1 and cosine of sun incident angle
图 18 不同阴影形状下的太阳电池阵输出电流
Figure 18. Output currents of solar array with different shadow patterns
参数 数值 短路点电流Isc/A 0.17123 短路点导数dsc -0.87479 开路点电压Voc/V 2.71 开路点导数doc -5000.5 最大功率点电流Im/A 0.16725 最大功率点电压Vm/V 2.41 电池片尺寸/(mm×mm) 50×38 电流温度系数a/(A·℃-1) 0.011×10-3 
下载: 导出CSV
表 2 旁路二极管和隔离二极管参数
Table 2. Parameters of bypass diode and block diode
参数 数值 理想因子n 1.95 二极管饱和电流Io/A 0.9×10-8
下载: 导出CSV
表 3 航天器轨道参数
Table 3. Orbit parameters of spacecraft
参数 数值 轨道高度/km 393 轨道倾角/(°) 42 太阳入射角(太阳矢量与轨道面夹角)/(°) 0~60 轨道环境光强/(W·m-2) 1353 太阳电池阵温度/℃ 75
下载: 导出CSV
-
[1] RAUSEHENBACH H S. 太阳电池阵设计手册[M]. 张金熹, 廖春发, 傅德棣, 等译. 北京: 中国宇航出版社, 1987: 20-77.RAUSEHENBACH H S.Solar array design handbook[M]. ZHANG J X, LIAO C F, FU D L, et al, translated.Beijing:China Astronautic Publishing House, 1987:20-77(in Chinese). [2] 马世俊.卫星电源技术[M].北京:中国宇航出版社, 2005:23-89.MA S J.Satellite power system technology[M]. Beijing:China Astronautic Publishing House, 2005:23-89(in Chinese). [3] 刘志全, 杨淑利, 濮海玲.空间太阳电池阵的发展现状及趋势[J].航天器工程, 2012, 21(6):112-118. http://www.cnki.com.cn/Article/CJFDTOTAL-HTGC201206023.htmLIU Z Q, YANG S L, PU H L.Development and trend of space solar array technology[J]. Spacecraft Engineering, 2012, 21(6):112-118(in Chinese). http://www.cnki.com.cn/Article/CJFDTOTAL-HTGC201206023.htm [4] SEYEDMAHMOUDIAN M, MEKHILEF S, RAHMANI R, et al.Maximum power point tracking of partial shaded photovoltaic array using an evolutionary algorithm:A particle swarm optimization technique[J]. Journal of Renewable and Sustainable Energy, 2014, 6(23102):1-13. [5] 任筱强, 王鹏鹏.航天器组合体能量平衡分析系统设计及应用[J].航天器工程, 2013, 22(2):60-64. http://www.cnki.com.cn/Article/CJFDTOTAL-HTGC201302014.htmREN X Q, WANG P P.Design and implementation of energy balance analysis system for spacecraft combination[J]. Spacecraft Engineering, 2013, 22(2):60-64(in Chinese). http://www.cnki.com.cn/Article/CJFDTOTAL-HTGC201302014.htm [6] 孙永卫, 曹鹤飞, 原青云.月尘对太阳电池阵开路电压影响研究[J].太阳能学报, 2015, 36(36):551-555. http://www.cnki.com.cn/Article/CJFDTOTAL-TYLX201503005.htmSUN Y W, CAO H F, YUAN Q Y.Effect of lunar dust to open circuit voltage of solar cell array[J]. Acta Energiae Solaris Sinica, 2015, 36(36):551-555(in Chinese). http://www.cnki.com.cn/Article/CJFDTOTAL-TYLX201503005.htm [7] 李安寿, 张东来, 杨炀, 等.一种精确计算航天器本体对太阳电池阵遮挡的方法[J].宇航学报, 2013, 34(10):1403-1409. doi: 10.3873/j.issn.1000-1328.2013.10.015LI A S, ZHANG D L, YANG Y, et al.A method for accurately calculating the shadow of solar array shaded by spacecraft itself[J]. Journal of Astronautics, 2013, 34(10):1403-1409(in Chinese). doi: 10.3873/j.issn.1000-1328.2013.10.015 [8] 韩新月, 屈健, 郭永杰.温度和光强对聚光硅太阳电池特性的影响研究[J].太阳能学报, 2015, 36(7):1585-1590. http://www.cnki.com.cn/Article/CJFDTOTAL-TYLX201507009.htmHAN X Y, QU J, GUO Y J.Dependence of silicon concentrator solar cells parameters on temperature and light intensity[J]. Acta Energiae Solaris Sinica, 2015, 36(7):1585-1590(in Chinese). http://www.cnki.com.cn/Article/CJFDTOTAL-TYLX201507009.htm [9] DELLEUR A M, KERSLAKE T W.Electrical performance from bifacial illumination international space station photovoltaic array[J]. Journal of Spacecraft and Rockets, 2005, 42(1):171-176. doi: 10.2514/1.5660 [10] DELLEUR A M, KERSLAKE T W, LEVY R K.Managing space station solar array electrical hazards for sequential shunt unit replacement[J]. Journal of Propulsion and Power, 2006, 22(1):16-23. doi: 10.2514/1.13731 [11] 张臻, 沈辉, 李达.局部阴影遮挡的太阳电池组件输出特性实验研究[J].太阳能学报, 2012, 33(1):5-12. http://www.cnki.com.cn/Article/CJFDTOTAL-TYLX201201003.htmZHANG Z, SHEN H, LI D.Experimental study on characteristics of partial shaded solar module[J]. Acta Energiae Solaris Sinica, 2012, 33(1):5-12(in Chinese). http://www.cnki.com.cn/Article/CJFDTOTAL-TYLX201201003.htm [12] 翟载腾, 程晓舫, 杨臧健, 等.太阳电池一般电流模型参数的解析解[J].太阳能学报, 2009, 30(8):1078-1082. http://www.cnki.com.cn/Article/CJFDTOTAL-TYLX200908017.htmZHAI Z T, CHENG X F, YANG Z J, et al.Analytic solutions of solar cell model parameters[J]. Acta Energiae Solaris Sinica, 2009, 30(8):1078-1082(in Chinese). http://www.cnki.com.cn/Article/CJFDTOTAL-TYLX200908017.htm [13] 张忠政. 太阳电池应用理论研究[D]. 合肥: 中国科学技术大学, 2014.ZHANG Z Z.Theoretical study of solar cells utilization[D]. Hefei:University of Science and Technology of China, 2014(in Chinese). [14] MAHMOUD Y, EI-SAADANY E.Accuracy improvement of the ideal PV model[J]. IEEE Transactions on Sustainable Energy, 2015, 6(3):909-911. doi: 10.1109/TSTE.2015.2412694 [15] RAMAPRABHA R, MATHUR B L.A comprehensive review and analysis of solar photovoltaic array configurations under partial shaded conditions[J]. International Journal of Photoenergy, 2012, 12(6):1-16. [16] 程保义. 空间三结砷化镓太阳电池辐照衰减模型研究[D]. 天津: 南开大学, 2010.CHENG B Y.Research on the radiation model of space triple-junction solar cell[D]. Tianjin: Nankai University, 2010(in Chinese). -
下载:
点击查看大图
计量
- 文章访问数: 787
- HTML全文浏览量: 135
- PDF下载量: 560
- 被引次数: 0
