北京航空航天大学学报 ›› 2010, Vol. 36 ›› Issue (5): 509-512.

• 论文 • 上一篇    下一篇

反转轴间气膜密封动特性分析

  

  1. (北京航空航天大学 机械工程及自动化学院, 北京 100191)
  • 收稿日期:2010-06-15 出版日期:2010-05-30 发布日期:2010-06-07
  • 通讯作者: 王之栎(1961-),男,北京人,教授,WZHL_BUAA@163.com.

Dynamic characteristic analysis of the gas film seal in counter-rotating shafts

  • Received:2010-06-15 Online:2010-05-30 Published:2010-06-07

摘要: 用有限元法计算了双端面期末密封两端面的气膜刚度和阻尼,分析了密封跑道质量和主密封环质量对气膜刚度和阻尼的影响,并对瞬态扰动力作用下前密封跑道和主密封环的振动过程进行了讨论.结果表明:膜厚对气膜刚度和阻尼影响较大,在膜厚小于5μm下尤为明显;系统的自由振动频率主要由前密封跑道质量决定,主密封环质量对自由振动频率影响较小;同一密封跑道质量对应的不同环道质量比对系统振动的收敛时间影响不大.

Abstract: Two stiffness and damping of the seal were calculated with the finite element method; the influence of the racetrack and the primary seal ring mass on the stiffness and damping was analyzed; then the vibration process of the seal caused by transient force was analyzed. The results declare that film thickness has a great influence on the stiffness and damping, especially when the thickness is less than 5μm; free vibration frequency of the system is mainly decided by the mass of the seal racetrack, and the effect of the primary seal ring mass on free vibration frequency is neglected; the different ratio of the system mass with the same racetrack mass has a little influence on the convergent time of the vibrating system.


版权所有 © 《北京航空航天大学学报》编辑部
通讯地址:北京市海淀区学院路37号 北京航空航天大学学报编辑部 邮编:100191 E-mail:jbuaa@buaa.edu.cn
本系统由北京玛格泰克科技发展有限公司设计开发