-
摘要:
针对小通道并联管在沸腾传热过程中传热不稳定的问题,对小通道并联管在干涸时的热动力学特性进行研究。首先,通过观察小通道并联管内干涸点前后流型的转变,将流型分成环状预警区、干涸初始点区和雾状干涸区3个区域。对3个流型下并联通道沸腾传热过程中通道内工质干度和传热系数的变化进行分析,发现随着干涸的发展,通道沸腾传热系数下降明显。然后,对通道3个流型下的压降信号,通过自适应最优核时频表示法(AOK-TFR)、自回归(AR)模型功率谱分析法和递归图分析法进行分析,发现在干涸初始点区,通道内反复出现干涸现象,且回流现象严重。最后,通过对递归图分析法中特性参数归纳总结,得到干涸初始点区与环状预警区、雾状干涸区的区别,实现通过压降信号检测干涸的目的。研究结果可对小通道沸腾传热领域中的热动力学特性进行补充和完善。
Abstract:Aiming at the unstable heat transfer of mini-channel parallel tubes in boiling heat transfer process, the thermodynamic characteristics of mini-channel parallel tubes during dryout were studied. Firstly, by observing the transition of the flow pattern before and after the dryout in the parallel mini-channels, the flow pattern is divided into three areas:the annular warning zone, the initial dryout zone and the mist dryout zone. The changes of dryness and heat transfer coefficient of working medium in mini-channel parallel tubes under three flow patterns were analyzed. It was found that the boiling heat transfer coefficient decreased significantly with the development of dryout. Then, the pressure drop signals under the three flow patterns are collected and analyzed by the adaptive optimal kernel time-frequency representation (AOK-TFR), auto regression (AR) power spectrum and recurrence plots analysis method to obtain the dynamic characteristics of the corresponding flow pattern. It is found that in the initial point of dryout, the phenomenon of dryout occurs repeatedly in the channel, and the phenomenon of reflux is serious. Finally, by summarizing the characteristic parameters in the recurrence plots, the difference among the initial dryout zone, annular warning zone and the mist dryout area is obtained. Based on the distribution of the recursive eigenvalues, the different zones can be identified, and then the dryout can be predicted by the pressure drop signals. The research of this paper hopes to supplement and improve the thermodynamic characteristics in the field of mini-channel boiling heat transfer.
-
Key words:
- gas-liquid two-phase flow /
- dynamic characteristics /
- dryout /
- recurrence plots /
- recursive eigenvalue
-
表 1 R141b制冷剂物性参数
Table 1. Physical properties of R141b refrigerant
参数 沸点/℃ 分子量 比热/(kJ·(kg·℃)-1) 密度/(g·cm-3) 蒸发潜热/(kJ·kg-1) 数值 32.05 116.95 1.16 1.227 233.0 -
[1] 葛洋, 姜未汀.微通道换热器的研究及应用现状[J].化工进展, 2016, 35(s1):10-15. http://d.old.wanfangdata.com.cn/Periodical/hgjz2016z1003GE Y, JIANG W T.The research progress and application of the micro-channel heat exchanger[J].Chemical Industry and Engineering Progress, 2016, 35(s1):10-15(in Chinese). http://d.old.wanfangdata.com.cn/Periodical/hgjz2016z1003 [2] LIU Z, BI Q, YANG Z, et al.Critical heat flux of cyclohexane in uniformly heated minichannels with high inlet subcooling[J].Experimental Thermal and Fluid Science, 2015, 63:106-114. doi: 10.1016/j.expthermflusci.2015.01.012 [3] WU Z, LI W.A new predictive tool for saturated critical heat flux in micro/mini-channels:Effect of the heated length-to-diameter ratio[J].International Journal of Heat and Mass Transfer, 2011, 54(13):2880-2889. http://cn.bing.com/academic/profile?id=bd1743cb07382333dc6fea442a7b205e&encoded=0&v=paper_preview&mkt=zh-cn [4] 彭传新, 陈炳德, 卓文彬, 等.自然循环临界热流密度实验现象及分析[J].核动力工程, 2017, 38(3):7-11. http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=hdlgc201703002PENG C X, CHEN B D, ZHUO W B, et al.Phenomenon and analysis of natural circulation CHF[J].Nuclear Power Engineering, 2017, 38(3):7-11(in Chinese). http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=hdlgc201703002 [5] 宗露香, 徐进良, 刘国华.微通道内流动沸腾不稳定性影响因素实验研究[J].高校化学工程学报, 2015, 29(1):90-95. doi: 10.3969/j.issn.1003-9015.2015.01.013ZONG L X, XU J L, LIU G H.Experimental study on the flowboiling instability governing parameters in microchannel[J].Journal of Chemical Engineering of Chinese Universities, 2015, 29(1):90-95(in Chinese). doi: 10.3969/j.issn.1003-9015.2015.01.013 [6] 杜保周, 孔令健, 郭保仓, 等.微肋阵通道内流动沸腾CHF特性[J].化工学报, 2018, 69(5):1989-1998. http://d.old.wanfangdata.com.cn/Periodical/hgxb201805022DU B Z, KONG L J, GUO B C, et al.Critical heat flux characteristics during flow boiling in a micro channel with micro pin fins[J].CIESC Journal, 2018, 69(5):1989-1998(in Chinese). http://d.old.wanfangdata.com.cn/Periodical/hgxb201805022 [7] 毛宇飞, 郭烈锦, 白博峰, 等.螺旋管内高压汽水两相流动沸腾干涸点的研究[J].工程热物理学报, 2011, 32(7):1145-1148. http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=gcrwlxb201107016MAO Y F, GUO L J, BAI B F, et al.Experimental investigation on the dryout point for two-phase flow boiling of steam-water at high pressures in helical coils[J].Journal of Engineering Thermophysics, 2011, 32(7):1145-1148(in Chinese). http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=gcrwlxb201107016 [8] SHEN Z, SHI J, GAN Y, et al.Simulation of dryout phenomenon and transient heat transfer performance of the once-through steam generator based on heat transfer partition[J].Annals of Nuclear Energy, 2018, 115:268-279. doi: 10.1016/j.anucene.2018.01.045 [9] JIANG L, LIU J, ZHANG L, et al.A research on the dryout characteristics of CO2'S flow boiling heat transfer process in mini-channels[J].International Journal of Refrigeration, 2017, 83:131-142. doi: 10.1016/j.ijrefrig.2017.07.017 [10] SHI J, SUN B, YU X, et al.Modeling the full-range thermal-hydraulic characteristics and post-dryout deviation from thermodynamic equilibrium in once-through steam generators[J].International Journal of Heat and Mass Transfer, 2017, 109:266-277. doi: 10.1016/j.ijheatmasstransfer.2017.02.007 [11] STATHAM B A, NOVOG D R.The effects of transient conditions on the onset of intermittent dryout during blowdown[J].Nuclear Engineering and Design, 2017, 317:118-132. doi: 10.1016/j.nucengdes.2017.02.025 [12] BAO H, GUO Y, LIU S, et al.Experimental study on the dryout point and post-dryout heat transfer in square channel[J].Fusion Engineering and Design, 2018, 136(B):1012-1018. http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=48492f1fe82e93e55a9fd75a7cfc7925 [13] DALKILIÇA S, ÖZMAN C, SAKAMATAPAN K, et al.Experimental investigation on the flow boiling of R134a in a multi-microchannel heat sink[J].International Communications in Heat and Mass Transfer, 2018, 91:125-137. doi: 10.1016/j.icheatmasstransfer.2017.12.008 [14] QU W, MUDAWAR I.Measurement and correlation of critical heat flux in two-phase micro-channel heat sinks[J].International Journal of Heat and Mass Transfer, 2004, 47(10-11):2045-2059. doi: 10.1016/j.ijheatmasstransfer.2003.12.006 [15] ECKMANN J P, KAMPHORST S O, RUELLE D.Recurrence plots of dynamical systems[J].Europhysics Letters, 1987, 4 (9):973-977. doi: 10.1209/0295-5075/4/9/004