Influence of ice accretion on leading edge of wings on stability and controllability of large aircraft
-
摘要:
机翼结冰影响飞机的操稳特性和飞行性能,对飞行安全造成危害。基于实验数据构建了典型的不同结冰严重程度的机翼前缘积冰冰形,采用高精度数值模拟方法得到背景飞机机翼前缘积冰的气动数据,建立了飞机六自由度非线性动力学模型,在此基础上设计了俯仰角保持、滚转角保持及高度保持模式的自动驾驶仪闭环仿真系统。通过开环仿真,分析了不同程度积冰对飞机配平特性、纵向长短周期模态及横航向模态的影响,比较了不同程度积冰情形下飞机动态响应的差异。通过闭环仿真,研究了积冰对3种模式下自动驾驶性能的影响。仿真结果表明:积冰对飞机配平特性、模态特性及开环动态响应特性均会造成一定的不良影响,威胁飞行安全。
Abstract:Ice accretion on the wings can affect the operational characteristics and flight performance of the aircraft, posing a hazard to flight safety. Based on the experimental data, the typical ice shapes with different icing severity on the leading edge of wings are constructed. The high-precision numerical simulation method is used to obtain the aerodynamic data of the background aircraft due to ice accretion, and the aircraft six-degree-of-freedom nonlinear dynamics model is established. On this basis, an autopilot closed-loop simulation system with three modes, namely, pitch attitude hold mode, roll attitude hold mode and altitude hold mode, is designed. Through the open-loop simulation, the different severity of ice accretion effects on aircraft trimming characteristics, longitudinal long and short period modal and lateral modal are analyzed, and the differences of aircraft dynamic response under different severity of ice accretion are compared. By using the closed-loop simulation, the influence of ice accretion on the autopilot performance under three modes is studied. The simulation results show that the ice accretion has an adverse effect on the stability and controllability of aircraft, including trimming characteristics, modal characteristics and open-loop dynamic response characteristics of aircraft, and threatens the flight safety.
-
Key words:
- ice accretion on wings /
- large aircraft /
- stability and controllability /
- autopilot /
- flight safety
-
表 1 不同积冰情形下的飞机配平参数
Table 1. Aircraft trim parameters under different ice accretion conditions
积冰情形 配平迎角/(°) 升降舵偏角/(°) 油门偏度/% 干净外形 6.83 -4.37 29.36 中度结冰 8.03 -2.17 36.90 重度结冰 8.67 -1.84 45.73 表 2 不同积冰情形下的飞机本体纵向长短周期模态特征参数
Table 2. Longitudinal long- and short-period modal characteristic parameters of aircraft body under different ice accretion conditions
积冰情形 ωnsp/(rad·s-1) ζsp ωnp/(rad·s-1) ζp CAP/(rad·s-2·g-1) 干净外形 1.7775 0.4566 0.0822 0.0282 7.3921 0.4274 中度结冰 1.4944 0.4962 0.1031 0.0381 6.0303 0.3703 重度结冰 1.5219 0.4907 0.0957 0.0557 6.4009 0.3618 表 3 不同积冰情形下的飞机本体横航向模态特征参数
Table 3. Lateral modal characteristic parameters of aircraft body under different ice accretion conditions
积冰情形 τR/s λS τS/s ωnDR/(rad·s-1) ζDR τDR/s 干净外形 0.1551 -0.0018 553.7114 1.2671 0.1965 4.0157 中度结冰 0.1636 0.0066 150.8256 1.3061 0.2137 3.5833 重度结冰 0.1676 0.0019 540.3449 1.2665 0.2123 3.7196 -
[1] REEHORST A L, JR ADDY H E, COLANTONIO R O.Examination of icing induced loss of control and its mitigations: AIAA-2010-8140[R]. Reston: AIAA, 2010. [2] CEBECI T.Effects of environmentally imposed roughness on airfoil performance: NASA CR 179639[R]. Washington, D.C.: NASA, 1981. [3] BRAGG M B, GREGOREK G M.Wind tunnel investigation of airfoil performance degradation due to icing: AIAA-82-0582[R]. Reston: AIAA, 1982. [4] BRAGG M B, ZAGULI R J, GREGOREK G M.Wind tunnel evaluation of airfoil performance using simulated ice shapes: NASA CR 167960[R]. Washington, D.C.: NASA, 1982. [5] BRAGG M B, COIRIER W J.Detailed measurements of the flowfield in the vicinity of an airfoil with glaze ice: AIAA-85-0409[R]. Reston: AIAA, 1985. [6] BRAGG M B, COIRIER W J.Aerodynamic measurements of an airfoil with simulated glaze ice: AIAA-86-0484[R]. Reston: AIAA, 1986. [7] BRAGG M B, SPRING S A.An experimental study of the flowfield about an airfoil with glaze ice: AIAA-87-0100[R]. Reston: AIAA, 1987. [8] BRAGG M B, KHODADOUST A.Experimental measurements in a large separation bubble due to a simulated glaze ice accretion: AIAA-88-0116[R]. Reston: AIAA, 1988. [9] BRAG M B, KHODADOUST A.Effect of simulated glaze ice on a rectangular wing: AIAA-89-0750[R]. Reston: AIAA, 1989. [10] KHODADOUST A.A flow visualization study of the leading edge separation bubble on a NACA 0012 airfoil with simulated glaze ice[D]. Columbus: Ohio State University, 1987. [11] RANAUDO R J.Performance degradation of a typical twin engine commuter type aircraft in measured natural icing conditions: AIAA-84-0179[R]. Reston: AIAA, 1984. [12] RANAUDO R J, MIKKELSEN K L, MCKNIGHT R C, et al.The measurement of aircraft performance and stability and control after flight through natural icing conditions: AIAA-86-9758[R]. Reston: AIAA, 1986. [13] POTAPCZUK M G, GERHART P M.Progress in the development of a Navier-Stokes solver for evaluation of iced airfoil performance: AIAA-85-0410[R]. Reston: AIAA, 1985. [14] POTAPCZUK M G.Navier-Stokes computations for a NACA 0012 airfoil with leading edge ice: AIAA-87-0101[R]. Reston: AIAA, 1987. [15] POTAPCZUK M G.Navier-Stokes analysis of airfoils with leading-edge ice accretions[D]. Akron: The University of Akron, 1989. [16] ZAMAN K B, POTAPCZUK M G.The low frequency oscillation in the flow over a NACA 0012 airfoil with an iced leading edge[M]//MUELLER T J.Low Reynolds number aerodynamics.Berlin: Springer-Verlag, 1989: 271-282. [17] HILTNER D W.A nonlinear aircraft simulation of ice contaminated tailplane stall[D]. Columbus: Ohio State University, 1998. [18] SIBILSKI K, LASEK M, LADYZYNSKA-KOZDRAS E, et al.Aircraft climbing flight dynamics with simulated ice accretion: AIAA-2004-4948[R]. Reston: AIAA, 2004. [19] CUNNINGHAM M A.A simplified icing model for simulation and analysis of dynamic effects[D]. Morgantown: West Virginia University, 2012. [20] 王明丰, 王立新, 黄成涛.积冰对飞机纵向操稳特性的量化影响[J].北京航空航天大学学报, 2008, 34(5):592-595. http://bhxb.buaa.edu.cn/CN/abstract/abstract9149.shtmlWANG M F, WANG L X, HUANG C T.Computational effects of ice accretion on aircraft longitudinal stability and control[J]. Journal of Beijing University of Aeronautics and Astronautics, 2008, 34(5):592-595(in Chinese). http://bhxb.buaa.edu.cn/CN/abstract/abstract9149.shtml [21] 袁坤刚, 曹义华.结冰对飞机飞行动力学特性影响的仿真研究[J].系统仿真学报, 2007, 19(9):1929-1932. doi: 10.3969/j.issn.1004-731X.2007.09.009YUAN K G, CAO Y H.Simulation of ice effect on aircraft flight dynamics[J]. Journal of System Simulation, 2007, 19(9):1929-1932(in Chinese). doi: 10.3969/j.issn.1004-731X.2007.09.009 [22] 蒋天俊.结冰对飞机飞行性能影响的研究[D].南京: 南京航空航天大学, 2008. http://cdmd.cnki.com.cn/Article/CDMD-10287-2009054739.htmJIANG T J.Study on the effect of icing on aircraft flight performance[D]. Nanjing: Nanjing University of Aeronautics and Astronautics, 2008(in Chinese). http://cdmd.cnki.com.cn/Article/CDMD-10287-2009054739.htm [23] 王起达.结冰后飞机的纵向稳定性和操纵性研究[D].南京: 南京航空航天大学, 2009. http://cdmd.cnki.com.cn/Article/CDMD-10287-2010081957.htmWANG Q D.Study on longitudinal stability and maneuverability of aircraft after icing[D]. Nanjing: Nanjing University of Aeronautics and Astronautics, 2009(in Chinese). http://cdmd.cnki.com.cn/Article/CDMD-10287-2010081957.htm [24] 张智勇.结冰飞行动力学特性与包线保护控制律研究[D].南京: 南京航空航天大学, 2006. http://cdmd.cnki.com.cn/article/cdmd-10287-2006118911.htmZHANG Z Y.Research on iced aircraft flight dynamics characteristics and envelope protection control law[D]. Nanjing: Nanjing University of Aeronautics and Astronautics, 2006(in Chinese). http://cdmd.cnki.com.cn/article/cdmd-10287-2006118911.htm [25] 邵元培, 车竞, 丁娣.大飞机机翼结冰对飞行动力学特性影响研究[J].飞行力学, 2018, 36(1):12-15. http://d.old.wanfangdata.com.cn/Periodical/fxlx201801003SHAO Y P, CHE J, DING D.Study on the influence of wing icing on flight dynamics characteristics of large aircraft[J]. Flight Dynamics, 2018, 36(1):12-15(in Chinese). http://d.old.wanfangdata.com.cn/Periodical/fxlx201801003 [26] BRAGG M B, HUTCHISON T, MERRET J.Effect of ice accretion on aircraft flight dynamics: AIAA-2000-0360[R]. Reston: AIAA, 2000. [27] SONNEVELDT L.Nonlinear F-16 model description[R]. Delft: Delft University of Technology, 2010. [28] 刘世前.现代飞机飞行动力学与控制[M].上海:上海交通大学出版社, 2014:145-150.LIU S Q.Flight dynamics and control of modern air-crafts[M]. Shanghai:Shanghai Jiao Tong University Press, 2014:145-150(in Chinese). [29] US Air Force.US military specification: Flying qualities of piloted airplanes: MIL-F-8785C[S]. Philadelphia: Naval Publications and Form Center, 1982.