| Citation: | LI Hongwei, WANG Yacheng, HONG Wenpeng, et al. Experiment on thermodynamic characteristics of parallel mini-channel tube' dryout[J]. Journal of Beijing University of Aeronautics and Astronautics, 2019, 45(8): 1495-1503. doi: 10.13700/j.bh.1001-5965.2018.0633(in Chinese)
|
Aiming at the unstable heat transfer of mini-channel parallel tubes in boiling heat transfer process, the thermodynamic characteristics of mini-channel parallel tubes during dryout were studied. Firstly, by observing the transition of the flow pattern before and after the dryout in the parallel mini-channels, the flow pattern is divided into three areas:the annular warning zone, the initial dryout zone and the mist dryout zone. The changes of dryness and heat transfer coefficient of working medium in mini-channel parallel tubes under three flow patterns were analyzed. It was found that the boiling heat transfer coefficient decreased significantly with the development of dryout. Then, the pressure drop signals under the three flow patterns are collected and analyzed by the adaptive optimal kernel time-frequency representation (AOK-TFR), auto regression (AR) power spectrum and recurrence plots analysis method to obtain the dynamic characteristics of the corresponding flow pattern. It is found that in the initial point of dryout, the phenomenon of dryout occurs repeatedly in the channel, and the phenomenon of reflux is serious. Finally, by summarizing the characteristic parameters in the recurrence plots, the difference among the initial dryout zone, annular warning zone and the mist dryout area is obtained. Based on the distribution of the recursive eigenvalues, the different zones can be identified, and then the dryout can be predicted by the pressure drop signals. The research of this paper hopes to supplement and improve the thermodynamic characteristics in the field of mini-channel boiling heat transfer.
| [1] |
葛洋, 姜未汀.微通道换热器的研究及应用现状[J].化工进展, 2016, 35(s1):10-15. http://d.old.wanfangdata.com.cn/Periodical/hgjz2016z1003
GE Y, JIANG W T.The research progress and application of the micro-channel heat exchanger[J].Chemical Industry and Engineering Progress, 2016, 35(s1):10-15(in Chinese). http://d.old.wanfangdata.com.cn/Periodical/hgjz2016z1003
|
| [2] |
LIU Z, BI Q, YANG Z, et al.Critical heat flux of cyclohexane in uniformly heated minichannels with high inlet subcooling[J].Experimental Thermal and Fluid Science, 2015, 63:106-114. doi: 10.1016/j.expthermflusci.2015.01.012
|
| [3] |
WU Z, LI W.A new predictive tool for saturated critical heat flux in micro/mini-channels:Effect of the heated length-to-diameter ratio[J].International Journal of Heat and Mass Transfer, 2011, 54(13):2880-2889. http://cn.bing.com/academic/profile?id=bd1743cb07382333dc6fea442a7b205e&encoded=0&v=paper_preview&mkt=zh-cn
|
| [4] |
彭传新, 陈炳德, 卓文彬, 等.自然循环临界热流密度实验现象及分析[J].核动力工程, 2017, 38(3):7-11. http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=hdlgc201703002
PENG C X, CHEN B D, ZHUO W B, et al.Phenomenon and analysis of natural circulation CHF[J].Nuclear Power Engineering, 2017, 38(3):7-11(in Chinese). http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=hdlgc201703002
|
| [5] |
宗露香, 徐进良, 刘国华.微通道内流动沸腾不稳定性影响因素实验研究[J].高校化学工程学报, 2015, 29(1):90-95. doi: 10.3969/j.issn.1003-9015.2015.01.013
ZONG L X, XU J L, LIU G H.Experimental study on the flowboiling instability governing parameters in microchannel[J].Journal of Chemical Engineering of Chinese Universities, 2015, 29(1):90-95(in Chinese). doi: 10.3969/j.issn.1003-9015.2015.01.013
|
| [6] |
杜保周, 孔令健, 郭保仓, 等.微肋阵通道内流动沸腾CHF特性[J].化工学报, 2018, 69(5):1989-1998. http://d.old.wanfangdata.com.cn/Periodical/hgxb201805022
DU B Z, KONG L J, GUO B C, et al.Critical heat flux characteristics during flow boiling in a micro channel with micro pin fins[J].CIESC Journal, 2018, 69(5):1989-1998(in Chinese). http://d.old.wanfangdata.com.cn/Periodical/hgxb201805022
|
| [7] |
毛宇飞, 郭烈锦, 白博峰, 等.螺旋管内高压汽水两相流动沸腾干涸点的研究[J].工程热物理学报, 2011, 32(7):1145-1148. http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=gcrwlxb201107016
MAO Y F, GUO L J, BAI B F, et al.Experimental investigation on the dryout point for two-phase flow boiling of steam-water at high pressures in helical coils[J].Journal of Engineering Thermophysics, 2011, 32(7):1145-1148(in Chinese). http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=gcrwlxb201107016
|
| [8] |
SHEN Z, SHI J, GAN Y, et al.Simulation of dryout phenomenon and transient heat transfer performance of the once-through steam generator based on heat transfer partition[J].Annals of Nuclear Energy, 2018, 115:268-279. doi: 10.1016/j.anucene.2018.01.045
|
| [9] |
JIANG L, LIU J, ZHANG L, et al.A research on the dryout characteristics of CO2'S flow boiling heat transfer process in mini-channels[J].International Journal of Refrigeration, 2017, 83:131-142. doi: 10.1016/j.ijrefrig.2017.07.017
|
| [10] |
SHI J, SUN B, YU X, et al.Modeling the full-range thermal-hydraulic characteristics and post-dryout deviation from thermodynamic equilibrium in once-through steam generators[J].International Journal of Heat and Mass Transfer, 2017, 109:266-277. doi: 10.1016/j.ijheatmasstransfer.2017.02.007
|
| [11] |
STATHAM B A, NOVOG D R.The effects of transient conditions on the onset of intermittent dryout during blowdown[J].Nuclear Engineering and Design, 2017, 317:118-132. doi: 10.1016/j.nucengdes.2017.02.025
|
| [12] |
BAO H, GUO Y, LIU S, et al.Experimental study on the dryout point and post-dryout heat transfer in square channel[J].Fusion Engineering and Design, 2018, 136(B):1012-1018. http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=48492f1fe82e93e55a9fd75a7cfc7925
|
| [13] |
DALKILIÇA S, ÖZMAN C, SAKAMATAPAN K, et al.Experimental investigation on the flow boiling of R134a in a multi-microchannel heat sink[J].International Communications in Heat and Mass Transfer, 2018, 91:125-137. doi: 10.1016/j.icheatmasstransfer.2017.12.008
|
| [14] |
QU W, MUDAWAR I.Measurement and correlation of critical heat flux in two-phase micro-channel heat sinks[J].International Journal of Heat and Mass Transfer, 2004, 47(10-11):2045-2059. doi: 10.1016/j.ijheatmasstransfer.2003.12.006
|
| [15] |
ECKMANN J P, KAMPHORST S O, RUELLE D.Recurrence plots of dynamical systems[J].Europhysics Letters, 1987, 4 (9):973-977. doi: 10.1209/0295-5075/4/9/004
|
Figures(12) / Tables(1)
Copyright © Journal of Beijing University of Aeronautics and Astronautics
Address: Editorial Department of Journal of Beijing University of Aeronautics and Astronautics, 37 Xueyuan Road, Haidian District, Beijing Post Code: 100191 Email: jbuaa@buaa.edu.cn
Supported by:
Beijing Renhe Information Technology Co., Ltd.
DownLoad:
