电机泵阀作动系统的分级压力控制及效率分析

付永领; 张卫卫; 纪友哲

电机泵阀作动系统的分级压力控制及效率分析

1.
北京航空航天大学机械工程及自动化学院, 北京 100191
2. 北京航空航天大学自动化科学与电气工程学院, 北京 100191
3. 中国石油集团钻井工程技术研究院钻井机械所, 北京 100195

基金项目: 国家自然科学基金资助项目(50675009)

详细信息

作者简介:
付永领(1966-),男,河北迁西人,教授,fuyongling@126.com.

中图分类号: TH 137
计量
- 文章访问数: 2648
- HTML全文浏览量: 143
- PDF下载量: 853
- 被引次数: 0
出版历程
- 收稿日期: 2010-08-06
- 网络出版日期: 2012-12-30

Dual-stage pressure control and efficiency analysis of motor-pump-valve coordinated control actuation system

1.
School of Mechanical Engineering and Automation, Beijing University of Aeronautics and Astronautics, Beijing 100191, China
2. School of Automation Science and Electrical Engineering, Beijing University of Aeronautics and Astronautics, Beijing 100191, China
3. Drilling Mechanical Department, CNPC Drilling Research Institute, Beijing 100195, China

摘要

摘要: 针对飞机作动系统中效率较低,发热严重的情况,分析了电机泵阀并联协调控制作动系统中系统压力与系统效率的关系,提出了采用分级压力节能控制,即对电机泵组和阀控单位设定不同的最高压力,并根据作动系统的要求来确定系统采用的控制单元;用AMESim软件进行仿真验证和分析.结果显示,采用分级压力控制系统的发热量分别为单独高压阀控制和电机泵控发热量的27.9%和34.1%,明显地降低系统温升,减少了系统的发热损失,提高了系统的效率,从而增加了系统的寿命,保障了系统的安全性和可靠性.
- 作动器 /
- 功率电传 /
- 电液作动器 /
- 分级压力控制 /
- AMESim仿真
Abstract: Based on the low efficiency and the significant heat loss of the aircraft actuating system, the relationship of pressure and efficiency was analyzed in the motor-pump-valve coordinated control actuation system. The method of the dual-stage pressure energy-saving control was proposed, that was, the different maximum pressures were set in the motor-pump and valve unit, and the control unit was determined by the requirement of the actuator system. The simulation and analysis were down by the AMESim software. The results indicate that the heat generated by the dual-stage pressure control system is only 27.9% and 34.1% of that generated by the high pressure valve control unit and the motor-pump separately. This method can obviously reduce the temperature increasing and heat losses of the system, the efficiency of the system can be improved, and consequently increase system life and maintain the security and reliability of the system.
- actuators /
- power by wire /
- electro-hydraulic actuator(EHA) /
- control of the dual-stage pressure /
- AMESim simulation

HTML全文

参考文献(1)

[1] 付永领,齐海涛,王利剑,等.混合作动系统的工作模式研究[J].航空学报,2010,31(6):1177-1184 Fu Yongling,Qi Haitao,Wang Zhanlin,et al.Research on operating modes in hybrid actuation systems[J].Acta Aeronautica et Astronautica Sinica,2010,31(6):1177-1184(in Chinese) [2] Demarchi J N,Ohlson J.Lightweight hydraulic system development and flight test[R].SAE Preprints 801189,1980 [3] 王世富.智能泵源系统关键技术的研究[D].北京:北京航空航天大学自动化科学与电气工程学院,2004:11-15 Wang Shifu.The research on key technologies for intelligent hydraulic power system[D].Beijing:School of Automation Science and Electrical Engineering,Beijing University of Aeronautics and Astronautics,2004:11-15(in Chinese) [4] 纪友哲.电机-泵-阀联合控制作动器的研究[D].北京:北京航空航天大学自动化科学与电气工程学院,2008:19-23 Ji Youzhe.Research on motor-pump-valve combined control actuator[D].Beijing:School of Automation Science and Electrical Engineering,Beijing University of Aeronautics and Astronautics,2008:19-23(in Chinese) [5] 邢彤,杨华勇,龚国芳.盾构刀盘驱动液压系统效率对比研究[J].浙江大学学报:工学版,2010,44(2):359-363 Xing Tong,Yang Huayong,Gong Guofang.Efficiency comparative study for hydraulic drive system of cutter head in shield tunneling machine[J].Journal of Zhejiang University:Engineering Science,2010,44(2):359-363(in Chinese) [6] 陈辉,纪友哲,祁晓野,等.前馈模糊免疫算法在泵阀联合EHA压力环控制中的应用[J].四川大学学报:工程科学版,2010,42(3):184-188 Chen Hui,Ji Youzhe,Qi Xiaoye,et al.Application of feed forward fuzzy immune algorithm to pressure loop control of pump and valve combined EHA[J].Journal of Sichuan University:Engineering Science Edition,2010,42(3):184-188(in Chinese) [7] Kang R J,Jiao Z X,Wang S P,et al.Design and simulation of electro-hydrostatic actuator with a built-in power regulator[J].Chinese Journal of Aeronautics,2009,22(5):700-706 [8] 纪友哲,祁晓野,裘丽华,等.泵阀联合EHA低温升设计研究[J].系统仿真学报,2009,21(7):1950-1952 Ji Youzhe,Qi Xiaoye,Qiu Lihua,et al.Research on low temperature rise design of pump and valve combined EHA[J].Journal of System Simulation,2009,21(7):1950-1952(in Chinese) [9] 王占林.近代电气液压伺服控制[M].北京:北京航空航天大学出版社,2005:139-169 Wang Zhanlin.Modern electric-hydraulic servo control[M].Beijing:Beijing University of Aeronautics and Astronautics Press,2005:139-169(in Chinese) [10] Mileti J A,Lawhead P M.Controlled pressure pumps for more efficient hydraulic systems[C]//SAE Technical Paper Series.Warrendale,PA:SAE,1986:144-161 [11] Lawhead P M.Electro-modulated control of supply pressure in hydraulic systems[C]//SAE Technical Paper Series.Warrendale,PA:SAE,1991:1-17

施引文献

资源附件(0)

访问统计