充磁导致的超高速永磁同步电机不平衡磁拉力

李艳明; 郭宏; 谢清明; 钱浩

充磁导致的超高速永磁同步电机不平衡磁拉力

北京航空航天大学自动化科学与电气工程学院, 北京 100191

基金项目: 2008年度国家重大产业技术开发专项资助项目 (发改办高技[2009]606号)

详细信息

中图分类号: TM85
计量
- 文章访问数: 2375
- HTML全文浏览量: 193
- PDF下载量: 892
- 被引次数: 0
出版历程
- 收稿日期: 2012-06-21
- 网络出版日期: 2013-06-30

Unbalanced magnetic pull due to the magnetizing in super high speed permanent magnet synchronous machine

School of Automation Science and Electrical Engineering, Beijing University of Aeronautics and Astronautics, Beijing 100191, China

摘要

摘要: 转子永磁体充磁角度偏差导致的不平衡磁拉力对微型燃气轮机发电系统用超高速永磁同步电机的安全稳定运行有很大的影响.采用有限元数值分析方法,分别在不考虑转子偏心和考虑转子偏心的情况下,对由充磁角度偏差导致的超高速永磁同步电机不平衡磁拉力进行了计算和分析;将不平衡磁拉力的计算结果作为载荷,获得了超高速永磁同步电机空气轴承-转子系统的固有频率及振动特性.研究结果表明:转子系统在740 Hz附近发生共振,共振幅值随着转子磁芯充磁偏差角度的增大而增大;要保证转子系统安全可靠的工作,需要将磁芯的充磁角度偏差限制在5°以内.
- 微型燃气轮机发电系统 /
- 超高速永磁同步电机 /
- 不平衡磁拉力 /
- 充磁角度偏差 /
- 箔片空气轴承
Abstract: The unbalanced magnetic pull (UMP) due to the magnetizing angle deviation has a great impact on the safety and stability of the super high speed permanent magnet synchronous machine (PMSM) used in the microturbine generation system. Utilizing the numerical finite element method (FEM), the UMP due to the magnetizing angle deviation with and without the rotor eccentricity was analyzed respectively. Using the calculation results as loads, the natural frequencies and the vibration characteristics of the rotor supported by foil air bearing were obtained. The results show that the resonance frequency is near 740 Hz, and the resonance amplitude increases with the increase of the magnetizing angle deviation. To ensure the safety and reliability of the rotor system, the magnetizing angle deviation of the permanent magnet should be limited to less than 5 degrees.
- microturbine generation system /
- super high speed permanent magnet synchronous machine /
- unbalance magnetic pull /
- magnetizing angle deviation /
- foil bearings

HTML全文

参考文献(10)

[1]	Hong D K,Woo B C,Lee J Y,et al.Ultra high speed motor supported by air foil bearings for air blower cooling fuel cells[J].IEEE Transactions on Magnetics,2012,48(2):871-874
[2]	白晖宇,荆建平,孟光．电机不平衡磁拉力研究现状与展望[J]．噪声与振动控制,2009(6):5-7 Bai Huiyu,Jing Jianping,Meng Guang．Survey and outlook on the research of the unbalanced magnetic pull in the motors[J]．Noise and Vibration Control,2009(6):5-7 (in Chinese)
[3]	Li Weili,Tang Li, Zhang Xiaocheng,et al． Calculation and analysis of high-speed permanent magnetic generator unilateral magnetic force [C]//International Conference on Electrical Machines and Systems.Wuhan,China:IEEE,2008:3284-3288
[4]	Stol R L．Simple computational model for calculating the unbalanced magnetic pull on a two-pole turbogenerator rotor due to eccentricity[J]．IEE Proceedings-Electric Power Applications,1997,144(4):263-270
[5]	郭丹,何永勇,褚福磊．不平衡磁拉力及对偏心转子系统振动的影响[J]．工程力学,2003,20(2):116-121 Guo Dan,He Yongyong,Chu Fulei．The calculation of unbalanced magnetic pull and its effect on vibration of an eccentric rotor[J]．Engineering Mechanics,2003,20(2):116-121(in Chinese)
[6]	Pennacchi P,Frosini L．Dynamical behaviour of a three-phase generator due to unbalanced magnetic pull[J]．IEE Proceedings on Electric Power Applications,2005,1524(6):1389-1400
[7]	Czolczynski K．Rotordynamics of gas-lubricated journal bearing systems[M]．New York:Springer,2011:1-3,50-60
[8]	张广辉,刘占生．径向气体轴承-柔性转子耦合系统动力学研究[J]．航空动力学报,2010,25(6):1417-1426 Zhang Guanghui,Liu Zhansheng．Dynamic study of journal gas bearings-flexible rotor coupling system [J]．Journal of Aerospace Power,2010,25(6):1417-1426(in Chinese)
[9]	Lee Y B,Park D J,Kim C H,et al．Rotordynamic characteristics of a micro turbo generator supported by air foil bearings[J]．Journal of Micromechanics and Microengineering,2007(17):297-303
[10]	Lee Y B,Kim T H,Kim C H.Unbalance response of a super-critical rotor supported by foil bearings—comparison with test results [J]．Tribology Transactions,2004,47:54-60