Component map correction of aero-engine based on genetic algorithm
-
摘要: 研究了航空发动机部件特性修正技术,提出了一种基于变适应度函数的模型优化算法,以达到减小总体建模误差,提高模型精度的目的.在稳态模型的基础上,对引气系数、总压恢复系数和各部件的特性进行了修正,使修正后的模型输出与实验数据相一致.采用改进遗传算法,对交叉率和变异率进行了非线性自适应调整,并根据误差大小调整适应度加权系数,避免算法陷入局部最优,同时减小最大建模误差.仿真结果表明,修正后各实验参数平均误差从2.420 8%减小到0.321 7%,模型满足稳态误差小于2%的要求.Abstract: The components characteristic modification technology was studied. A model optimization algorithm based on changed fitness function was proposed to reduce the modeling error and improve the model accuracy. Based on the static model, characteristic correction coefficients of every component, air-entraining correction coefficients and pressure recovery correction coefficients were optimized to achieve high matching accuracy of engine model outputs to test data. The improved genetic algorithm with adaptive crossover rate and mutation rate was adopted, and the weighting coefficient in fitness function was adjusted according to the error. Then the trapping in local optimal solution was avoided and the maximum modeling error was reduced. Simulation results show that the average error of test parameters decrease from 2.420 8% to 0.321 7% after modification, and the model meets the requirements that the static error should be less than 2%.
-
[1] Kong C, Kho S,Ki J.Component map generation of a gas turbine using genetic algorithms[J].Journal of Engineering for Gas Turbines and Power,2004,128(1):92-96 [2] Kong C, Ki J.Components map generation of gas turbine engine using genetic algorithms and engine performance deck data[J].Journal of Engineering for Gas Turbines and Power,2007, 129(2): 312-317 [3] 杨欣毅, 刘海峰,董可海.依据试验数据求取航空发动机部件特性的新方法[J].航空计算技术,2009,39(3):48-51,55 Yang Xinyi,Liu Haifeng,Dong Kehai.A new component map generation method of aero engine based on experimental data[J].Aeronautical Computing Technique,2009,39(3):48-51,55(in Chinese) [4] Ghorbanian K, Gholamrezaei M.An artificial neural network approach to compressor performance prediction[J].Applied Energy,2008,86(7):1210-1221 [5] Li Y G, Pilidis P,Newby M A.An adaptation approach for gas turbine design-point performance simulation [J].Journal of Engineering for Gas Turbines and Power,2005,128(4):789-795 [6] 刘盾,江和浦, 都庆福.部件特性图的非线性最小二乘拟合修正[J].燃气涡轮试验与研究,2000,13(4):18-21 Liu Dun,Jiang Hepu,Du Qingfu.Component characteristics correction base on the nonlinear least-squares[J].Gas Turbine Experiment and Research,2000,13(4):18-21(in Chinese) [7] 白磊,陈思兵, 江和浦.基于模型辨识的发动机部件特性修正研究[J].燃气涡轮试验与研究,2009,22(3):37-39,13 Bai Lei,Chen Sibin,Jiang Hepu.Investigation on correction methods of aero-engine components characteristics based on model identification[J].Gas Turbine Experiment and Research,2009,22(3):37-39,13(in Chinese) [8] 杨欣毅,沈伟, 刘海峰,等.一种应用滑动最小二乘求取压气机特性的方法[J].航空动力学报,2009,24(8):1741-1746 Yang Xinyi,Shen Wei,Liu Haifeng,et al.Compressor characteristics generation method using moving least square[J].Journal of Aerospace Power,2009,24(8):1741-1746(in Chinese) [9] 蒋建军,鲁伟, 尹洪举,等.航空发动机部件特性自适应计算方法[J].航空计算技术,2008,38(4):11-13,17 Jiang Jianjun,Lu Wei,Yin Hongju,et al.Adaptive simulation of a missile engine component performance[J].Aeronautical Computing Technique,2008,38(4):11-13,17(in Chinese) [10] 肖洪,刘振侠, 廉筱纯.两种涡扇发动机部件特性自适应模型对比[J].中国民航大学学报,2008,26(3):17-19 Xiao Hong,Liu Zhenxia,Lian Xiaochun.Comparison of two simulation models of turbofan component performance[J].Journal of Civil Aviation University of China,2008,26(3):17-19(in Chinese) [11] Li Y G, Marinai L,Lo G E,et al.Multiple point adaptive performance simulation tuned to aerospace test-bed data[J].Journal of Propulsion and Power,2009,25(3):635-641 [12] 刘永葆,贺星,黄树红.基于改进遗传算法的燃气轮机自适应建模[J].航空动力学报,2012,27(3):695-700 Liu Yongbao,He Xing,Huang Shuhong.Adaptive simulation of gas turbine performance using improved genetic algorithm[J].Journal of Aerospace Power,2012,27(3):695-700(in Chinese) [13] Srinvas M, Patnaik L M.Adaptive probabilities of crossover and mutation in genetic algorithms [J].IEEE Trans on Systems,Man and Cybemetics,1994,24(4):656-667 [14] 金晶,苏勇. 一种改进的自适应遗传算法[J].计算机工程与运用,2005,41(18):64-69 Jin Jing,Su Yong.An improved adaptive genetic algorithm [J].Computer Engineering and Applications,2005,41(18): 64-69(in Chinese)
点击查看大图
计量
- 文章访问数: 1129
- HTML全文浏览量: 61
- PDF下载量: 479
- 被引次数: 0