加速度作用下环路热管工作特性实验

谢永奇; 于印; 解立垚; 高红霞; 余建祖

doi:10.13700/j.bh.1001-5965.2014.0049

加速度作用下环路热管工作特性实验

doi: 10.13700/j.bh.1001-5965.2014.0049

1.
北京航空航天大学航空科学与工程学院, 北京 100191
2. 北京航空航天大学人机工效与环境控制国防重点学科实验室, 北京 100191

基金项目: 中央高校基本科研业务费资助项目(YWF-14-HKXY-019)

详细信息

通讯作者:
谢永奇(1979-),男,河南杞县人,讲师,xyq@buaa.edu.cn,主要研究方向为强化传热、电子设备热设计.

中图分类号: TB131
计量
- 文章访问数: 1278
- HTML全文浏览量: 121
- PDF下载量: 537
- 被引次数: 0
出版历程
- 收稿日期: 2014-01-23
- 网络出版日期: 2015-01-20

Experimental investigation on operational performance of loop heat pipe subjected to acceleration force

1.
School of Aeronautic Science and Engineering, Beijing University of Aeronautics and Astronautics, Beijing 100191, China
2. National Defense Key Discipline Laboratory of Ergonomics and Environmental Control, Beijing University of Aeronautics and Astronautics, Beijing 100191, China

摘要

摘要: 针对单储液器环路热管在过载加速度作用下可能出现的温度波动甚至无法运行的问题,基于恒加速度离心机系统,建立了双储液器环路热管(DCCLHP)工作特性实验台,实验研究了双储液器环路热管在重力场稳定运行后再施加过载加速度时的工作特性,分析了不同加热功率、不同加速度大小和方向对其运行性能的影响.结果表明,双储液器环路热管在加速度为7g时仍可达到稳定工作状态,加速度作用导致其稳定运行温度低于地面重力场的温度,且随加热功率和加速度不同,运行温度降低程度不同;加速度方向沿储液器2指向储液器1时其达到稳定状态所需时间比其反方向时更短.实验还观察到了加速度作用下冷凝器出口和液体管线出口温度波动现象.
- 环路热管 /
- 加速度场 /
- 双储液器 /
- 工作特性 /
- 实验
Abstract: To solve the problem of temperature oscillation, even operation failure when loop heat pipe with single compensation chamber was subjected to acceleration force, the experimental setup was built for testing the performance of dual compensation champers loop heat pipe (DCCLHP) based on the centrifugal machine system with constant acceleration. The operational characteristics of DCCLHP were researched when it was subjected to acceleration force after reaching the steady state at gravity field. The influence of different heat load, acceleration value and direction on the performance was analyzed. The results show that the operation of DCCLHP can get to the steady state at 7 g acceleration field. The steady operation temperature at elevated acceleration field is lower than that at gravity field and the heat load and acceleration force have an impact on the decrease. It takes less time along the acceleration direction from compensation chamber 2 to compensation chamber 1 than in the opposite direction when it gets to the steady operation. Moreover, the temperature oscillations at the outlet condenser and liquid line occur as a result of the acceleration effect.
- loop heat pipe /
- acceleration field /
- dual compensation chamber /
- operating characteristics /
- experiment

HTML全文

参考文献(16)

[1]	Xie L Y,Xie Y Q,Yu J Z,et al.Effects of rotational acceleration on flow and heat transfer in straight and swirl microchannels[J].Heat and Mass Transfer,2011,48(6):953-964.
[2]	Zaghdoudi M C,Sarno C.Investigation on the effects of body force environment on flat heat pipes[J].Journal of Thermophysics and Heat Transfer,2001,15(1-4):384-394.
[3]	Maydanik Y F.Loop heat pipes[J].Applied Thermal Engineering,2005,25(5-6):635-657.
[4]	Wang G H,Mish Kinis D,Nikanpour D.Capillary heatloop technology:space applications and recent Canadianactivities[J].Applied Thermal Engineering,2008,28(4):284-303.
[5]	Pastukhov V G,Maidanik Y F,Vershinin C V,et al.Miniature loop heat pipes for electronics cooling[J].Applied Thermal Engineering,2003,23(9):1125-1135.
[6]	Ku J,Ottenstein L,Kaya T,et al.Testing of a loop heat pipe subjected to variable accelerating forces,part 1:start-up[C]//30th International Conference on Environmental Systems.Warrendale,PA:SAE,2000:2000-01-2488.
[7]	Ku J,Ottenstein L,Kaya T,et al.Testing of a loop heat pipe subjected to variable accelerating forces,part 2:temperature stability[C]//30th International Conference on Environmental Systems.Warrendale,PA:SAE,2000:2000-01-2489.
[8]	Fleming A J,Thomas S K,Yerkes K L,et al.Titanium-water loop heat pipe operating characteristics under standard and elevated acceleration fields[J].Journal of Thermophysics and Heat Transfer,2010,24(1):184-198.
[9]	Yerkes K L,Scofield J D,Courson D L,et al.An experimental investigation into the transient performance of a titanium-water loop heat pipe subjected to a steady-periodic acceleration field[C]//50th AIAA Aerospace Sciences Meeting including the New Horizons Forum and Aerospace Exposition.Reston,VA:AIAA,2012:1-37.
[10]	凤健婷,林贵平,柏立战.双储液器环路热管稳态运行特性的试验研究[J].航空学报,2010,31(8):1558-1564.Feng J T,Lin G P,Bai L Z.Experimental investigation on steady-state operating characteristics of a dual compensation chamber loop heat pipe[J].Acta Aeronautica et Astronautica Sinica,2010,31(8):1558-1564(in Chinese).
[11]	Phillips A L F,Fale J E,Gernert N J,et al.Loop heat pipe qualification for high vibration and high-g environments[C]//36th AIAA Aerospace Sciences Meeting and Exhibit.Reston,VA:AIAA,1998:1- 6.
[12]	Gluck D,Gerhart C,Stanley S.Characterization of a high capacity,dual compensation chamber loop heat pipe[C]//Space Technology and Application International Forum.Albuquerque,New Mexico:AIP,1999:943-948.
[13]	张红星,苗建印,邵兴国.双储液器环路热管的设计与实验研究[J].中国空间科学技术,2009,29(5):8- 41.Zhang H X,Miao J Y,Shao X G.Development and test results of dual compensation chamber loop heat pipe[J].Chinese Space Science and Technology,2009,29(5):8- 41(in Chinese).
[14]	Lin G P,Zhang H X,Shao X G,et al.Development and test results of a dual compensation chamber loop heat pipe[J].Journal of Thermophysics and Heat Transfer,2006,20(4):825-834.
[15]	Lin G P,Li N,Bai L Z,et al.Experimental investigation of a dual compensation chamber loop heat pipe[J].International Journal of Heat and Mass Transfer, 2010,53(15-16):3231- 3240.
[16]	张红星,林贵平,丁汀,等.环路热管温度波动现象的实验分析[J].北京航空航天大学学报,2005,31(2):116-120.Zhang H X,Lin G P,Ding T,et al.Experimental investigation on temperature oscillation of loop heat pipes[J].Journal of Beijing University of Aeronautics and Astronautics,2005,31(2):116-120(in Chinese)