氧化物涂层对航天器材料原子氧剥蚀的防护

张雯; 易敏; 沈志刚; 赵小虎

氧化物涂层对航天器材料原子氧剥蚀的防护

北京航空航天大学航空科学与工程学院, 北京 100191

详细信息

中图分类号: V258
计量
- 文章访问数: 1576
- HTML全文浏览量: 234
- PDF下载量: 416
- 被引次数: 0
出版历程
- 收稿日期: 2012-08-26
- 修回日期: 2012-11-26
- 网络出版日期: 2013-08-30

Protection against atomic oxygen erosion of oxide coatings for spacecraft materials

School of Aeronautic Science and Engineering, Beijing University of Aeronautics and Astronautics, Beijing 100191, China

摘要

摘要: 采用磁控溅射方法在航天器常用材料聚酰亚胺(Kapton)表面沉积无机氧化物涂层(TiO₂和SiO₂),来提高材料的抗原子氧剥蚀性能.通过选择试验材料和参数,优化了沉积涂层的工艺,以克服容易产生裂纹的缺点.对材料进行了原子氧效应地面模拟试验,结果表明,在Kapton上沉积涂层后,质量损失下降了2个数量级.另外,有涂层的Kapton表面基本没有变化并且没有出现裂纹.其中,TiO₂由于热膨胀系数更接近Kapton,比SiO₂的防护效果更好.
- 原子氧 /
- 航天器 /
- 防护 /
- 涂层 /
- 磁控溅射
Abstract: To improve the atomic oxygen resistance, TiO₂ and SiO₂ coatings were deposited on polyimide (Kapton), a common material of spacecrafts using magnetron sputtering. The technic of depositing coating was optimized by selecting the experimental material and parameters to overcome the disadvantage of cracking. The atomic oxygen effect experiments were carried out. The results show that the mass loss of Kapton decreases by two orders of magnitude after depositing coatings. In addition, surfaces of coated Kapton change little and display low tendency of cracking. The thermal expansion coefficient of TiO₂ is closer to that of Kapton, so TiO₂ can provide better protection comparing with SiO₂.
- atomic oxygen /
- spacecraft /
- protection /
- coating /
- magnetron sputtering

HTML全文

参考文献(13)

[1]	Reddy M R.Review:effect of low earth orbit atomic oxygen on spacecraft materials[J].J Mater Sci,1995,30:281-307
[2]	Hedin A E.MSIS-86 thermospheric model[J].J Geophys Res,1987,92(A5):4649-4662
[3]	Duo S,Li M,Zhou Y,et al.Investigation of surface reaction and degradation mechanism of Kapton during atomic oxygen exposure[J].J Mater Sci Technol,2003,19(6):535-539
[4]	Peter P N,Gregory J C,Swann J T.Effects on optical systems from interactions with oxygen atoms in low earth orbits[J].Appl Opt,1986,25(8):1290-1298
[5]	Packirisamy S,Schwam D,Litt M H.Review:atomic oxygen resistant coatings for low earth orbit space structures[J].J Mater Sci,1995,30:308-320
[6]	Dworak D P,Soucek M D.Protective space coatings:a creamer approach for nanoscale materials[J].Prog Org Coat,2003,47:449-457
[7]	Cooper R,Upadhyaya H P,Minton T K,et al.Protection of polymer from atomic-oxygen erosion using Al2O3 atomic layer deposition coatings[J].Thin Solid Film,2008,516:4036-4039
[8]	Banks B A,Rutledge S K.SiO_x coatings for atomic oxygen protection of polyimide Kapton in low earth orbit .AIAA-92-2151-CP,1992
[9]	Banks B A,Snyder A,Miller S K,et al.Atomic-oxygen undercutting of protected polymers in low earth orbit[J].J Spacecraft Rockets,2004,41(3):335-339
[10]	Singh K,Krishnamurthy N,Suri A K.Adhesion and wear studies of magnetron sputtered NbN films[J].Tribology International,2012,50:16-25
[11]	Wang T,Diao X,Wang X.Inhomogeneous optoelectronic and microstructure property distribution across the substrate of ZnO:Al films deposited by room temperature magnetron sputtering[J].Appl Surf Sci,2001,257:9773-9779
[12]	Zhou Y,Xie Z,Ma Y,et al.Growth and characterization of Ta/Ti bi-layer films on glass and Si (1 1 1) substrates by direct current magnetron sputtering[J].Appl Surf Sci,2012,258:7314-7321
[13]	沈志刚,赵小虎,陈军,等.灯丝放电磁场约束型原子氧效应地面模拟试验设备[J].航空学报,2000,21(5):425-430 Shen Zhigang,Zhao Xiaohu,Chen Jun,et al.Ground-based atomic oxygen effects simulation facility with the filament discharge and bound of magnetic field[J].Acta Aeronautica et Astronautica Sinica,2000,21(5):425-430(in Chinese)