燃气动力弹跳机器人在不同地面弹跳能力

栾云广; 王化明; 赵东标; 汪洋; 陈峰洪

doi:10.13700/j.bh.1001-5965.2015.0365

燃气动力弹跳机器人在不同地面弹跳能力

doi: 10.13700/j.bh.1001-5965.2015.0365

1.
南京航空航天大学机电学院, 南京 210016
2. 流体动力与机电系统国家重点实验室, 杭州 310027

基金项目: 流体动力与机电系统国家重点实验室开放基金(GZKF-201406);江苏省自然科学基金(BK2011735)

详细信息

作者简介:
栾云广男,博士研究生。主要研究方向:弹跳机器人。E-mail:luanyunguang@nuaa.edu.cn;王化明男,博士,教授。主要研究方向:介电型EAP驱动器,弹跳机器人。Tel.:025-84892503 E-mail:hmwang@nuaa.edu.cn;赵东标男,博士,教授,博士生导师。主要研究方向:数控机床,机器人控制。E-mail:zdbme@nuaa.edu.cn

通讯作者:
王化明,Tel.:025-84892503 E-mail:hmwang@nuaa.edu.cn

中图分类号: TP242.3
计量
- 文章访问数: 1197
- HTML全文浏览量: 300
- PDF下载量: 746
- 被引次数: 0
出版历程
- 收稿日期: 2015-06-03
- 网络出版日期: 2016-05-20

Hopping ability of gas fuel powered hopping robot on different grounds

1.
College of Mechanical and Electrical Engineering, Nanjing University of Aeronautics and Astronautics, Nanjing 210016, China
2. State Key Laboratory of Fluid Power Transmission and Control, Hangzhou 310027, China

摘要

摘要: 燃气动力弹跳机器人具有很强的越障能力,但不同特性地面对其弹跳性能影响较大。针对上述问题,对燃气动力弹跳机器人起跳过程的动力学模型进行理论与试验分析。首先建立了机器人起跳动力学模型,利用Hunt-Crossley模型对机器人脚与地面的作用力进行分析;然后构建试验平台,对模拟硬黏土、草地进行静态、动态力学特性测试,得到相应的力学参数;最后对弹跳机构在刚性地面、模拟硬黏土和模拟草地分别进行弹跳分析与试验。在一定充气压力条件下(丙烷0.01 MPa、一氧化二氮0.21 MPa)燃烧室内燃后压力基本相同(最大压力约3.1 MPa),而弹跳机构(总重为3.55 kg)在刚性地面和硬黏土地面的弹跳高度分别为2.0 m和1.4 m,在草地地面相对充气压力为0 MPa条件下,其弹跳高度为0.1 m。结果表明,机器人在松软的地面较刚性地面弹跳高度较低,且模拟3种地面的弹跳试验结果与分析结果较为吻合。
- 燃气动力弹跳机器人 /
- 动力学分析 /
- 地面力学特性 /
- 接触 /
- 试验分析
Abstract: Gas fuel powered hopping robot has great traverse obstacle ability, but its performance is affected by ground mechanical properties greatly. For exploring ground influence on the hopping robot performance, the dynamic model of the robot is analyzed by theory and experiments during take-off process. Firstly, hopping robot taking off dynamic model is set up and the reaction force between ground and robot foot is analyzed according to the Hunt-Crossley contact model. Secondly, the test platform is set up to test the static and dynamic contact model relative parameters on hard clay soil and grass soil. Finally, the hopping mechanism test experiments on rigid ground, hard clay ground and grass ground are conducted and analyzed respectively. When 0.01 MPa propane and 0.21 MPa nitrous oxide are injected in hopping actuator, 3.55 kg hopping mechanism can hop 2.0 m and 1.4 m on rigid ground and hard clay ground respectively, while the pressures of the chamber are basically the same. The maximum pressure inside the chamber is about 3.1 MPa. On the grass ground, the hopping height is 0.1 m when 0 MPa gas source is filled in the chamber. The result shows that robot hops lower on soft ground than rigid ground and experiments fit well with the analysis results on the three grounds.
- gas fuel powered hopping robot /
- dynamic analysis /
- ground mechanical property /
- contact /
- experimental analysis

HTML全文

参考文献(20)

[1]	尹军茂,陈殿生,沈奇.仿蝗虫跳跃机构设计与分析[J].北京航空航天大学学报,2013,39(10):1348-1353. YIN J M,CHEN D S,SHEN Q.Design and analysis of locust-like jumping mechanism[J].Journal of Beijing University of Aeronautics and Astronautics,2013,39(10):1348-1353(in Chinese).
[2]	柴辉,葛文杰,魏敦文,等.一种间歇式弹跳机器人的机构设计与跳跃性能分析[J].机械工程学报,2012,48(13):19-26. CHAI H,GE W J,WEI D W,et al.Mechanism design and hopping performance analysis of an intermittent hopping robot[J].Journal of Mechanical Engineering,2012,48(13):19-26(in Chinese).
[3]	ZHAO J,XU J,GAO B,et al.MSU jumper:A single-motor-actuated miniature steerable jumping robot[J].IEEE Transactions on Robotics,2013,29(3):602-614.
[4]	KOVA M,SCHLEGEL M,ZUFFEREY J C,et al.Steerable miniature jumping robot[J].Autonomous Robots,2010,28(3):295-306.
[5]	SCARFOGLIERO U,STEFANINI C,DARIO P.Design and development of the long-jumping[C]//IEEE International Conference on Robotics and Automation.Piscataway,NJ:IEEE Press,2007:467-472.
[6]	DUBOWSKY S,KESNER S,PLANTE J S,et al.Hopping mobility concept for search and rescue robots[J].Industrial Robot,2008,35(3):238-245.
[7]	NOH M,KIM S W,AN S,et al.Flea-inspired catapult mechanism for miniature jumping robots[J].IEEE Transactions on Robotics,2012,28(5):1007-1018.
[8]	WANG H M,LUAN Y G,OETOMO D,et al.Design, analysis and experimental evaluation of a gas-fuel-powered actuator for robotic hoppers[J].IEEE/ASME Transactions on Mechatronics,2015,20(5):2264-2275.
[9]	SALTON J R,BUERGER S,MARRON L,et al.Urban hopper[C]//SPIE Defense Security and Sensing International Society for Optics and Photonics.Bellingham:SPIE,2010:76920Z.
[10]	ACKERMAN E.Boston dynamics sand flea robot demonstrates astonishing jumping skills[EB/OL].IEEE Spectrum Robotics Blog(2012-03-28)[2015-06-03].http://spectrum.ieee.org/automaton/robotics/military-robots/boston-dynamics-sand-flea-demonstrates-astonishing-jumping-skills/.
[11]	DING L,DENG Z,GAO H,et al.Planetary rovers' wheel-soil interaction mechanics:New challenges and applications for wheeled mobile robots[J].Intelligent Service Robotics,2011,4(1):17-38.
[12]	IRANI R A,BAUER R J,WARKENTIN A.A dynamic terramechanic model for small lightweight vehicles with rigid wheels and grousers operating in sandy soil[J].Journal of Terramechanics,2011,48(4):307-318.
[13]	LEVER J H,SHOOP S A,BERNHARD R I.Design of lightweight robots for over-snow mobility[J].Journal of Terramechanics,2009,46(3):67-74.
[14]	YEOMANS B,SAAJ C M,VAN WINNENDAEL M.Walking planetary rovers:Experimental analysis and modeling of leg thrust in loose granular soils[J].Journal of Terramechanics,2013,50(2):107-120.
[15]	张克通.轮式移动弹跳机器人研究[D].南京:南京航空航天大学,2010:17. ZHANG K T.Research on wheeled hopping robot[D].Nanjing:Nanjing University of Aeronautics and Astronautics,2010:17(in Chinese).
[16]	TILIAKOS N,TYLL J S,HERDY R,et al.Development and testing of a nitrous oxide/propane rocket engine:AIAA-2001-3258[R].Reston:AIAA,2001.
[17]	BEKKER M G.Land locomotion on the surface of planets[J].ARS Journal,1962,32(11):1651-1659.
[18]	HUNT K,CROSSLEY F.Coefficient of restitution initerpreted as damping in vibroimpact[J].Journal of Applied Mechanics,1975,42(2):440-445.
[19]	WONG J Y.Theory of ground vehicles[M].Hoboken,NJ:John Wiley & Sons,2008:65.
[20]	DING L,GAO H,DENG Z,et al.Foot-terrain interaction mechanics for legged robots:Modeling and experimental validation[J].The International Journal of Robotics Research,2013,32(13):1585-1606.