磁悬浮反作用飞轮磁轴承动反力分析及实验

刘强; 房建成; 韩邦成

磁悬浮反作用飞轮磁轴承动反力分析及实验

北京航空航天大学仪器科学与光电工程学院, 北京 100191

基金项目: 国家杰出青年科学基金资助项目(60825305)

详细信息

中图分类号: V 249.1
计量
- 文章访问数: 4695
- HTML全文浏览量: 124
- PDF下载量: 1196
- 被引次数: 0
出版历程
- 收稿日期: 2009-05-21
- 网络出版日期: 2010-07-30

Analysis and test of dynamic reaction of magnetic bearing reaction flywheel

School of Instrument Science and Opto-electronics Engineering, Beijing University of Aeronautics and Astronautics, Beijing 100191, China

摘要

摘要: 针对磁悬浮反作用飞轮转子系统,提出了一种描述混合磁轴承动反力的新模型.基于拉格朗日原理,将飞轮转子两去重面内不平衡质量矩等效至两端径向磁轴承位置,并与转子惯性轴偏离几何轴引起的离心力共同作用,得到磁轴承动反力.仿真结果表明:转子两不平衡质量矩大小相等时,其振幅从相位差φ_a-φ_b=0时的30μm减小至φ_a-φ_b=π时的10μm(减小了2/3),从转速为1000r/min时的5μm增加至5000r/min时的10μm(增加了1倍).测试实验结果与仿真结果一致,为飞轮系统高精度高稳定度控制奠定了基础.
- 磁轴承 /
- 飞轮 /
- 转子 /
- 动力学 /
- 仿真
Abstract: Aimed at the magnetic bearing reaction flywheel rotor system, a novel model was proposed to describe the dynamic reaction of hybrid magnetic bearing (HMB). Based on Lagrange principle, the unbalance mass moments distributed in two planes were equivalent to the positions of two radial HMBs. Incorporated with the effect of centrifugal force caused by its principal axis of inertia, the dynamic reaction of HMB was obtained. Simulation result show that the rotation amplitude of rotor was significantly dependent on the phase difference, angular velocity and unbalance mass moment. When the values of two unbalance mass moments were equal, for the phase difference of 0, the amplitude was high, near 30μm. However, with an increase in the phase difference to π, the amplitude of rotor diminished down to 10μm. In addition, the vibration amplitude of rotor was 5μm at speed of 1000 r/min, which was lower than one at speed of 5000 r/min.Tests had a good agreement with the numerical simulations, which shows how to improve the precision and stability of system, by decreasing the vibration amplitude of flywheel rotor.
- magnetic bearings /
- flywheels /
- rotors /
- dynamics /
- simulation

HTML全文

参考文献(1)

[1] 吴刚,刘昆,张育林.磁悬浮飞轮技术及其应用研究[J].宇航学报,2005,26(3):385-390 Wu Gang,Liu Kun,Zhang Yulin.Application and study of magnetic bearing flywheel technology[J].Journal of Astronautic,2005,26(3):385-390(in Chinese) [2] 房建成,孙津济.一种磁悬浮飞轮用新型永磁偏置径向磁轴承[J].北京航空航天大学学报,2006,32(11):1304-1307 Fang Jiancheng,Sun Jinji.New permanent magnet biased radial magnetic bearing in magnetic suspending flywheel application[J].Journal of Beijing University of Aeronautics and Astronautics,2006,32(11):1304-1307 (in Chinese) [3] Xu Yanliang,Dun Yueqin,Wang Xiuhe,et al.Analysis of hybrid magnetic bearing with a permanent magnet in the rotor by FEM[J].IEEE Transactions on Magnetics,2006,42(4):1363-1366 [4] Li Yong,Li Wei,Lu Yongping.Computer-aided simulation analysis of a novel structure hybrid magnetic bearing[J].IEEE Transactions on Magnetics,2008,44(10):2283-2287 [5] Pichot M A,Driga M D.Loss reduction strategies in design of magnetic bearing actuators for vehicle applications[J].IEEE Transactions on Magnetics,2005,41(1):492-496 [6] 田希晖,房建成,刘刚.一种磁悬浮飞轮增益预调交叉反馈控制方法[J].北京航空航天大学学报,2006,32(11):1029-1303 Tian Xihui,Fang Jiancheng,Liu Gang.Gain scheduling cross feedback control approach for magnetic suspending flywheel[J].Journal of Beijing University of Aeronautics and Astronautics,2006,32(11):1029-1303(in Chinese) [7] Husain I,Radun A,Nairus J.Unbalanced force calculation in switched-reluctance machines[J].IEEE Transactions on Magnetics,2000,36(1):330-338 [8] Duan Guangren,Wu Zhanyuan,Bingham C,et al.Robust magnetic bearing control using stabilizing dynamical compensators[J].IEEE Transactions on Industry Applications,2000,36(6):1654-1660 [9] Wang Chienchang,Yao Y D.Bias-magnetic force for vibration reduction of magnetic bearing motors[J].IEEE Transactions on Magnetics,2007,43(6):2486-2489 [10] 张涛,朱熀秋.无轴承永磁同步电机转子质量不平衡补偿控制[J].中国电机工程学报,2007,27(15):33-37 Zhang Tao,Zhu Huangqiu.Rotor’s mass unbalance compensation control in bearingless permanent magnet-type synchronous motors[J].Proceedings of CSEE,2007,27(15):33-37(in Chinese) [11] 韩邦成,房建成,郭家富.不平衡质量对磁悬浮CMG转子运动特性的影响分析及实验[J].宇航学报,2008,29(2):585-589 Han Bangcheng,Fang Jiancheng,Guo Jiafu.Simulation analysis and test of the influence of imbalance mass on magnetically suspended rotor[J].Journal of Astronautic,2008,29(2):585-589(in Chinese)

施引文献

资源附件(0)

访问统计